A rigging inspection report informed me that my boat’s gooseneck toggle and boom’s forward-end casting were worn. I enquired about replacement parts but was told they were likely to be unobtainable.
No single element in the system was worn to excess, but in combination there was a lot of slack.
The only DIY solution in cases such as these is to replace the fixings with slightly larger diameter pieces and then ream out the receiving parts to as tight a tolerance as possible.
The toggle connects the vertical pin with the horizontal pin in the gooseneck joint. Both pins were 10mm diameter. The next realistic metric size is 12mm but the imperial size 7 ⁄16in is 11.11mm. I found that a 7 ⁄16 bolt would not fit into either part, which shows how little wear it takes to make a lot of movement in a complex joint.
Bu hikaye Practical Boat Owner dergisinin October 2020 sayısından alınmıştır.
Start your 7-day Magzter GOLD free trial to access thousands of curated premium stories, and 9,000+ magazines and newspapers.
Already a subscriber ? Giriş Yap
Bu hikaye Practical Boat Owner dergisinin October 2020 sayısından alınmıştır.
Start your 7-day Magzter GOLD free trial to access thousands of curated premium stories, and 9,000+ magazines and newspapers.
Already a subscriber? Giriş Yap
Orca sink yacht in Strait of Gibraltar
Spain's maritime rescue service, Salvamento Maritimo, has reported that a 15m (49ft) yacht sank in Moroccan waters in the Strait of Gibraltar following interaction with a pod of orca.
No kill cord or lifejackets were worn during fatal powerboat crash
A kill cord and lifejacket are useless unless worn-that's the warning from the Marine Accident Investigation Branch (MAIB), following its investigation into a powerboat crash that killed a 32-year-old woman and five-year-old girl on 2 October 2022.
Multihull sail work
Brush up on multihull sailing skills before heading off on charter with Gavin Le Sueur's guide to spinnaker handling, tacking and gybing
Five top causes of engine failure and how to prevent them
Jake Kavanagh talks to Sea Start marine engineer Nick Eales about how to avoid the five major causes of an engine breakdown at sea
Sail the Atlantic with strangers
Would you sail across the Atlantic with someone you've just met? Ali Wood meets the cruising crews who've done just that
IZIBoat: simple sailing
Rupert Holmes sails an innovative catamaran design intended to widen participation in sailing among those with little time to get on the water in more conventional craft
30 WAYS TO GET AFLOAT
From tall ships to small dinghies, you needn't own a boat to sail. Ali Wood looks at the options, and how skippers can also find crew
Boats for restoring under £20,000
Duncan Kent picks the best sub-35ft sail and power boats to look for when aiming to undertake a restoration on a budget
Seaworthy dinghies for less than £500
For low cost traditionally-styled GRP trailer-sailers, consider the Foreland and the Otter available at bargain basement prices
Playing with coloured sails
Maintaining an hourglass-shaped balloon and ratcheting up the log numbers
